What does it mean when your spa heater is disabled?
Heater Flow is Reduced-means there is inadequate water flow to heater to carry heat away from the spa unit’s heating element. The heater is disabled. Check to determine conditions such as closed valves, suction flow restrictions, pump prime, low water level, trapped air and too many closed jets. Heater starts again after 1 min.
How to troubleshoot a problem with a Cal spa?
Troubleshooting 1 Message on the control panel. A message on the control panel may indicate a problem. 2 Problems starting up. Note: The priming procedure described here applies to Cal Spas built in 2013 and earlier. 3 Power and electrical problems. 4 Heat problems 5 Jet problems 6 Water pressure problems
What does it mean when your Spa is too hot?
Means that a temperature sensor detected temperatures that are too hot in the heater ( 118°f /47.8°C). The system shuts the spa down. Check to determine conditions such as closed valves, suction flow restrictions, pump prime, low water level, trapped air and too many closed jets.
What does it mean when your Spa is shut down for 15 minutes?
Means there isn’t enough water to start it or a possibility of a dry heater – spa is shut down for 15 minutes. Check to determine conditions such as closed valves, suction flow restrictions, pump prime, low water level, trapped air and too many closed jets.
Troubleshooting 1 Message on the control panel. A message on the control panel may indicate a problem. 2 Problems starting up. Note: The priming procedure described here applies to Cal Spas built in 2013 and earlier. 3 Power and electrical problems. 4 Heat problems 5 Jet problems 6 Water pressure problems
How much does a Cal spa heater cost?
CAL SPA 1 1/2 INCH 4 WAY, 5 PORT VALVE CALPLU21100050 $0.00 CAL SPA 1 1/2 INCH FLAPPER CLEAR WATER CHECK VALVE CALPLU21100140 $27.99 CAL SPA 1 1/2 INCH HEATER UNION SPLIT NUT CALHEA14700120 $3.95 CAL SPA 1 1/2 INCH HEATER UNION TAILPIECE CALHEA14700130 $3.00 CAL SPA 1 1/2 INCH HEATER UNION TAILPIECE O-RING CALHEA14700000 $1.49
What to do if your spa heater does not heat?
Once they are removed, tape them together; turn the thermostat dial down to the off position, and turn the power back on. Make sure the spa is on the heater/filter cycle and water is flowing from the jets, turn the thermostat dial up while watching the contactor, if it closes when doing this, then re-test the heater using the amp-meter.
How big is a Cal spa manifold heater?
CAL SPA 1 1/2 INCH LOOP MANIFOLD HEATER, 5.5kw CALHEA14100230 $0.00 CAL SPA 1 1/2 INCH SPRING CHECK VALVE CALPLU21100150 $29.54 CAL SPA 1 1/2 INCH STRAIGHT MANIFOLD HEATER, 5.5kw CALHEA14100220 $0.00 CAL SPA 1 HP CENTER DISCHARGE WET END CALPUM22200040
