How did my Ford F53 fuel pump die?
It all started when we crested a hill after a long climb on a 98 degree F day. The motorhome died completely. We coasted down the mountain with a dead engine and came to a stop in the chain removal lane. The motorhome would start but it would sputter and die in a few seconds and the symptoms just screamed fuel to me.
When did Ford replace fuel pump in motorhome?
Our motorhome has a build date of 3 ⁄ 96 and before 6 ⁄ 96 Ford used a gear driven pump. After 6 ⁄ 96 they replaced this pump with a completely different turbine pump.
Where is the fuel filter on a 1999 Southwind 35?
The fuel filter is located on the drivers side frame rail just behind the front tire. I removed the front line and pushed a hose onto the fuel filter tube.. I then removed the fuel pump relay, and then used a jumper wire to to apply power to the pump.
How many fuel lines does a motorhome fuel pump have?
The fuel lines are quick disconnect and you need the proper tool. They are the same as A/C quick disconnect tools and I had some on hand to do the fuel filter. You need different sizes so get the kit. The fuel pump has 3 lines connected, pump, return and generator.
It all started when we crested a hill after a long climb on a 98 degree F day. The motorhome died completely. We coasted down the mountain with a dead engine and came to a stop in the chain removal lane. The motorhome would start but it would sputter and die in a few seconds and the symptoms just screamed fuel to me.
Our motorhome has a build date of 3 ⁄ 96 and before 6 ⁄ 96 Ford used a gear driven pump. After 6 ⁄ 96 they replaced this pump with a completely different turbine pump.
Why does my Ford fuel pump keep clogging up?
So using anything but the updated ford pump is a waste of money. Some people blame the fuel sock. There is a filter sock that the pump draws up fuel through and if you have some rust in the tank break away it can clog the sock. This wasnt the case for us. The sock was discolored but not even close to clogged.
Can a fuel pump be removed from a Motorcraft?
Removing the filter and vent tube completely sucks as there is no easy way to access the clamps. Just do your best and be patient and eventually you’ll get a ratchet on it. Once you get off the filler tubes you can drop the tank from the rear and then there is enough room to access the fuel pump. The new motorcraft pump
How do you replace a fuel pump in a Ford F53?
You put a small floor jack under the rear of the tank, loosen the front center tank bolt, remove the front and rear straps and then remove the rear tank bolt. Then you have to remove the filler and vent tube. Removing the filter and vent tube completely sucks as there is no easy way to access the clamps.
The fuel lines are quick disconnect and you need the proper tool. They are the same as A/C quick disconnect tools and I had some on hand to do the fuel filter. You need different sizes so get the kit. The fuel pump has 3 lines connected, pump, return and generator.
