Are there any problems with the Workhorse chassis?

Some chassis will have defects while others do not. Some Workhorse chassis owners have said that they have not had trouble with their brakes. This is said despite a recall that was done in 2006. But that does not mean that the Workhorse brakes did not have a problem.

When did workhorse change to the W series?

Then in 2005, Workhorse again made changes to their chassis and started the W series. This series used 2 digits to indicate how many thousands of pounds the chassis could tow safely. Another design change had Workhorse putting leaf springs on all four corners of the chassis.

What are the facts about the Chevy workhorse?

One of the most important facts about the Chevrolet Workhorse chassis is that it replaced the old Chevrolet P-30, P-32 truck/van chassis. It was so durable that it was a favorite component of many RV manufacturers. Another sad fact is that it has since been discontinued.

Are there any problems with a Chevrolet workhorse RV?

Minor problems have involved bad or dirty ABS sensors, ABS indicator light malfunction and so on. One RV owner reported that their front right side brake was giving them a little difficulty. The cause of that could be a hose collapsing or that the wheel just gets too hot while on the road.

What kind of engine does a Chevy workhorse have?

I am looking at a 2010 with Chevy Workhorse engine /Allison transmission. I need some feed back should I or should not. I just heard the same back fire noise in my 2003 pace arrow, 22000 miles, at the time I heard the noise I was pushing it pretty hard, steep hill, 4300rpms, air conditioning going full blast.

Is the GM 454 Vortec and 8.1 workhorse engines?

Nurse Barbara, the 454 and the 8.1 are built on the same block. I am not sure but I beleive the 454 is a throttle body injection and the 8.1 is a multi port injection. And yes either one will do well on a coach up to 34 or 35 feet. more then that you not preform too well. Thank you for that reply. You are the only one who knew that much.

What kind of car is a workhorse W22?

I am working on a 2002 Workhorse W22, 8.1. The owners were heading home to Wisconson in this rig they had purchased at a small “Mom and Pop” car lot in Ocala, Florida. They made it to our sister shop in Gainesville, Florida, and the rig went into ” reduced power” mode, with no throttle response.

Where to find P32 chassis workhorse parts?

(Please provide your VIN# and a detailed description of what you are looking for.) Use this search to find parts in the category you are currently in. Use the search at the top of the page to search entire site. 00332815 – Bracket – Engine and Bell Housing Reinforcement .. 00346897 – Bushing – Rear Sway Bar ..

What are the parts for a workhorse car?

Part# 12389921 Description: Brand New Workhorse/Chevrolet Rear Axle Shaft Gasket. Ap.. 12471447 – Gasket – Rear Axle Housing Cover ..

Which is better Chevy workhorse or Freightliner chassis?

It offers a smoother ride in some cases, less noise and has better maneuverability and driving capabilities. Also, the Freightliner chassis may help you get better gas mileage. The Freightliner, in some cases, produced up to 10.2 mpg while the workhorse only got about 7.2 mpg.

What kind of parking brake does a workhorse have?

The parking brake is spring applied and hydraulic release. The automatic electric/hydraulic parking system controls the transmission/propeller shaft mounted parking brake. Workhorse utilizes two designs of automatic apply park brake systems, the J71 and J72.

Is there a website for workhorse RV parts?

The most recent news that has been found has been a Workhorse parts website dated to 2016 and an RV forum dated to 2017. The do have a website, find it here, and it is dated to 20919 but there is little information on the landing page.

What are the parts of a 2002 workhorse?

Part# 12387291 Description: Brand New Workhorse/Chevrolet Rear Differential Pinion Seal (.. Part# 12389921 Description: Brand New Workhorse/Chevrolet Rear Axle Shaft Gasket. Ap.. 12471447 – Gasket – Rear Axle Housing Cover ..

What are the brake parts for a workhorse?

– 1GBKP37… – 1GBLP37… These are Genuine Workhorse Parts to Complete a Full Brake Job on a 1996-2005 Workhorse or GM P32 Motor Home Chassis. No questions have been asked about this product.

What are the parts for a 2003 P32 chassis?

Part# 105297U – You must ship us your cluster for us to remove the mileage chip t.. Part# 11514597 Description:M10 X 1.5 .. 11562588 – Plug Asm – Oil Pan Drain ..

– 1GBKP37… – 1GBLP37… These are Genuine Workhorse Parts to Complete a Full Brake Job on a 1996-2005 Workhorse or GM P32 Motor Home Chassis. No questions have been asked about this product.

Part# 105297U – You must ship us your cluster for us to remove the mileage chip t.. Part# 11514597 Description:M10 X 1.5 .. 11562588 – Plug Asm – Oil Pan Drain ..

Where can I get Workhorse chassis replacement parts?

Shop for Original Workhorse Custom Chassis Replacement Parts from an Authorized Workhorse Parts Dealer here. If you do not see what you are looking for here, please use the Contact Form and we would be happy to assist you to get the part (s) you need.

What kind of wiring diagram does Damon daybreak use?

Damon Daybreak Wiring Diagram Keys Can Access Control Car Auto10 Caubro Warmi Fr Diagram Suzuki Df6 Wiring Full Version Hd Quality Ritualdiagrams Politopendays It Ef 3443 Damon Challenger Motorhome Wiring Diagram Diagram 1998 Coachmen Mirada Rv Electrical Wiring Full Version Hd Quality Ritualdiagrams Politopendays It

Are there any safety warnings for workhorse parts?

There are no reviews for this product. The state of California requires that this warning be posted for people purchasing products that reside in California. WARNING: Products may contain one or more chemicals known in the State of California to cause cancer and/or birth defects or other reproductive harm.

What kind of chassis does Winnebago RV have?

Winnebago is one manufacturer that has used this chassis. Its adventurer model has it and it tows vehicles through mountainous areas without that much difficulty. Then outside of Winnebago, the Sportscoach model has it as well. The performance on that RV is basically second to none.

Why is my AC not working in my coach?

The most common problem when the compressor runs and the fan does not start is a blown fuse and that is caused by a failed fan motor mounted on the condenser coil mounted out side the coach. Underneath the front or in the rear in the area of the radiator.

What kind of car is the Allegro Bay?

2000 Tiffin Motorhomes Allegro Bay 36DB, 2000 Tiffin Allegro Bay 36DB Double-slide Class A Gas MotorhomeFeatures and options include:.Ford Triton V10 Tiffin Allegro Bay 37QDB, 2007 Tiffin Allegro Bay 37QDB Quad Slide-Out Class A Diesel Motorhome.

Where can I buy parts for my workhorse RV?

Our staff is experienced and helpful for repair shops around the country, or RV owners that just need a little guidance. We also offer a full range of Genuine and Aftermarket parts for the Workhorse Chassis through our parts distribution site

What kind of motorhome is Tiffin Allegro Bay?

2006 Tiffin Motorhomes Allegro Bay 37DB, Used 2006 Tiffin Allegro Bay 37DB Class A Gas Motorhome The 2006 Tiffin Allegro Bay 37DB features 2 slides… 2007 Tiffin Allegro Bay 37DB, Priced to move! Call 866-733-2829 NOW!Air Conditioning, AM FM CD, Automatic Leveling Jacks, Backup Camera, Backup Monito…

When does the workhorse 8.1L gas 2004 start?

Please leave us a question or feedback about what we have done or can do to help you. 01/27/2017, 04:57:40 PM, Workhorse 8.1L gas 2004. Starter won’t engage when temperature is below 40 degrees. Battery tests good, cleaned cable connections, tried auxiliary battery switch, clicked but no help.

Where can I buy Winnebago touring coach parts?

Lichtsinn RV also sells Winnebago RV Parts for the Winnebago Touring Coach, Class B Line of Winnebago Motor Homes which includes: the Winnebago Travato, Winnebago Era, Winnebago Revel , Winnebago Boldt and the Winnebago Solis.

How to buy a workhorse motor home Chas?

Save Thousands call us Toll Free 1 800 436 5851 00 WORKHORSE MOTOR HOME CHAS Vehicle Information Year: 2000 Make: WORKHORSE Model: MOTOR HOME CHAS Condition: Used ? ? Description REPAIRABLE VEHICLE BUY NOW ONLY $9500 These vehicles are offered by the insurance companies as a “Buy Now” prior to the “Live” Auction they hold each week.

What kind of engine does a workhorse Class A motorhome have?

Workhorse Class A Motorhome I have a 8.1 liter GM engine in… I have a 8.1 liter… I have a 8.1 liter GM engine in a 2005 Workhorse chassis motorhome. The engine has Banks low restriction air intake and exhaust systems. I frequently get a 0131 O2 sensor low voltage code. The engine will immediately start to run badly.

What do you need to know about workhorse RV?

We offer Technical Assistance for your Workhorse RV Chassis. This technical support includes Drivability, Auto Park Brake, Steering and Handling, and Electrical issues. Our staff is experienced and helpful for repair shops around the country, or RV owners that just need a little guidance.

What’s the difference between a Class A and Class A workhorse?

You have to be careful if you’re buying a used Class A on a Workhorse chassis because there are several different Workhorse chassis & they all have the 8.1L V8. The difference is the tranny. The standard Workhorse W18 chassis has a GVWR of 18,000 lbs & comes with a 4 speed automatic.

What are the problems with the Winnebago destination?

2008 Winnebago Destination on a UFO chassis. Having problems with the auto brake release. When the yellow button on the dash is pushed to release the brake you can physically feel the brake release but the dash displays “parking brake on” with a red ! flashing. When this occurs my brake lights illuminate and stay on all the time.

What kind of shocks does a Winnebago destination 39W have?

Hello, I have a 2008 Winnebago Destination 39W, on a 2007 UFO Chassis. Of course it’s a 8.1 with a Allison 6 spd. I want to know, what the torque value is for the Koni 99B-3209 front shocks, upper and lower.

What are the performance parts for a workhorse?

Raylar’s performance package for Workhorse chassis equipped motorhomes & RVs is a simple, reliable, bolt-on performance system. Our RV performance package consists of Raylar aluminum cylinder heads, high-torque camshaft and high strength roller rocker arms.

When did Chevy stop making the Workhorse chassis?

Then Fleetwood used it on their 2002 Southwind and we saw no complaints so far about the work and performance of the Chevy Workhorse chassis. The chassis was discontinued about the same time GM stopped producing the 8.1-liter engine for vehicles.

What was the year of the Winnebago workhorse?

2002 Winnebago Workhorse W22, 2002 Winnebago Workhorse W22 Class C Motorhome, 2002 Winnebago Workhorse W22 Class C Motorhome, used. Side entry across from dinette and sofa, recliner next to entrance, side kitchen, bedroom in the rear attached to bathroom. 93k miles. $19000 BELOW THE NADA LOW-RETAIL!

Are there any class a RVs with Workhorse chassis?

There are some Class A RVs with the new Workhorse chassis but that has not had a long term influence. It was hoped that since 2015 the company would produce about 21,800 units each year but those plans seemed to have been shelved when the new owners took over. What Workhorse Chassis do I have? (How to find out)

Why does my workhorse W22 chassis not work?

If it’s only the dash lights not working the problem may be the switch. I have a 2003. When you are looking at the one you found under the hood, look to the right and up.

Where are the fuse boxes on a workhorse chassis?

The manual says the fuse box location is determined by the builder. It also says there are two on this chassis. One under the drivers side by the parking break (I found this one :-)) and one in the Engine compartment. I located the fuse diagram in the manual and the one under the drivers side didn’t seem to match the picture.

How much horsepower does a workhorse motorhome have?

Our vortec engine kit for the Workhorse series of motorhomes & RVs provide a complete system allowing you to achieve incredible increases in the power, reliability and efficiency from your engine. Our stage 1 Workhorse chassis RV / motorhome performance package bumps the 496 / 8.1L to 440 horsepower & 490 ft-lbs of torque.

What’s the price of a 2004 Fleetwood pace Arrow?

The base suggested retail price of the 2004 Pace Arrow 37C is $135,639, and with those options it came to $138,180.

Is the Fleetwood pace Arrow a diesel pusher?

Wrong! Totally redesigned and built on the Workhorse W22 chassis, the 2004 Fleetwood Pace Arrow has all the earmarks of a high-line diesel pusher. These features include new graphics, a roofline that is 5 inches higher than that of the previous model, and 22.5-inch wheels and tires.

How many Windows does the Fleetwood pace arrow have?

All told, the 2004 Pace Arrow has eight windows “” nine, if you count the two windows adjacent to the driver’s seat. They lend the impression that the motorhome’s walls consist mostly of glass. This impression remains with you whether you’re traveling or at an RV park with the slideouts extended.

What kind of steel is in Fleetwood pace Arrow?

The Pace Arrow’s ladder-type frame is built from 50,000-psi steel, and the 1/4-inch-thick, 9.6-inch channel rails extend the full length of the coach for more weight capacity and greater stability and structural integrity. All of this helps to support the three slideouts in the 2004 Pace Arrow.

What to do if your workhorse has a brake recall?

Woodlodge, if you register as the new owner with Workhorse you can see if the brake recall campaign is open or if it has been completed. You may be able to call them with your VIN and get the same info. It’s a good idea to register with them anyway so you will get any new recalls or other info sent to you.

Which is better workhorse or Freightliner RV chassis?

The Freightliner, in some cases, produced up to 10.2 mpg while the workhorse only got about 7.2 mpg. Then the Workhorse equipped RV may be a bit more expensive than the Freightliner. Other RV owners preferred the Workhorse chassis as it gave them a better overall performance than the Freightliner did.

What are the features of a 2002 Southwind?

MOTORHOMES – In addition to what is standard, 2002 models include DSS manual lift, awing, 2 A/C’s, 5.5KW generator, hydrallic manual 4pt levelers, VCR, remote rear view mirror driver side door, ultra leather driver/passenger seats with power and 4 door refrigerator with ice maker (except M-32VS).

How big is a Southwind Class A motorhome?

Building Class A motorhomes, Southwind products are equipped with many of the amenities of home at the campground. Powered primarily with gasoline engine options, Southwind motorhomes are presented in lengths from 23.5 to 38 feet.

Is there an ABS light on my chassis?

I have a 2005 SunVoyager 8.1 gas Workhorse chassis which just came back from the dealer and I started showing the ABS light on the panel. I plugged in my code reader but it showed zero codes. I pushed the clear button any way but it did nothing.

When did workhorse make changes to their chassis?

In about 2000 or so, Workhorse widened the track on the P 32 which put the front tires in line with the outer rear tires. This upgrade should have also made the performance better. Then in 2005, Workhorse again made changes to their chassis and started the W series.

How much does a workhorse RV chassis weigh?

The sticker weight is 27,000 lb. Where can I find the chassis info? For the most complete information, to register your chassis with Workhorse and to check for any recalls affecting your chassis, call Workhorse with your chassis number: (877) 294-6773 or (248) 588-5300

When did Chevrolet workhorse get a new track?

In about 2000 or so, Workhorse widened the track on the P 32 which put the front tires in line with the outer rear tires. This upgrade should have also made the performance better.